Evening all, long time no visit - something of a winter hibernation.
Just come back from my first roadtrip of the season - bus ran great, used maybe half a pint of oil in 700-ish miles of tough and windy roads. The brakes have though, developed an odd and slightly alarming trait, one that began after a hard emergency stop: when I brake, I have a few seconds of resistance with the pedal pretty high, then it'll suddenly drop by maybe an inch. The time before the drop seems to vary according to how hard I'm braking. There's no loss of feeling - if anything, there's better bite and less effort when the pedal's lower, and I'm not seeing any leakage or anything.
New master cylinder a couple or three years ago, calipers overhauled at the same time, no drops in fluid level. I would have thought if it was a problem with either the booster or the vacuum from the engine I'd be feeling a loss of assistance rather than anything else...
Suggested starting points for investigation very welcome.
Brake weirdness - pedal drops...
-
- I'm New!
- Location: Noo Zelun' - left hand side...
- Contact:
- Status: Offline
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Brake weirdness - pedal drops...
1. Check brake fluid level in reservoir, top up if necessary.jalabert wrote: ↑Mon Nov 11, 2019 11:18 pmEvening all, long time no visit - something of a winter hibernation.
Just come back from my first roadtrip of the season - bus ran great, used maybe half a pint of oil in 700-ish miles of tough and windy roads. The brakes have though, developed an odd and slightly alarming trait, one that began after a hard emergency stop: when I brake, I have a few seconds of resistance with the pedal pretty high, then it'll suddenly drop by maybe an inch. The time before the drop seems to vary according to how hard I'm braking. There's no loss of feeling - if anything, there's better bite and less effort when the pedal's lower, and I'm not seeing any leakage or anything.
New master cylinder a couple or three years ago, calipers overhauled at the same time, no drops in fluid level. I would have thought if it was a problem with either the booster or the vacuum from the engine I'd be feeling a loss of assistance rather than anything else...
Suggested starting points for investigation very welcome.
a) adjust rear brakes specifically and carefully. draw out all adjusters equally (you can count threads looking in the holes) and adjust until the wheels are both difficult to turn. Make a note of the actual friction at each wheel.
b) apply the e-brake firmly and step on the brake pedal firmly a couple of times. You should sense that there is NO drop and it ain't gonna drop. Release e-brake.
c) now *check* the rotational friction of each wheel and report back if one or the other or both slackened noticeably
d) adjust both wheels to difficult-to-turn again, if necessary, then back off each individual star adjuster two clicks, do NOT screw up here, make sure both adjusters are going in the correct loosening direction! If the wheel has not come back to free rotation, adjust each star one tooth looser.
e) apply e-brake 5-6 clicks. Are the wheels sticky-to-turn like they were above? Go make it thus under the car at the equalizer bar. Do not worry if the equalizer bar is crooked, that is evidence of cable stretch, and does not tell you that one wheel is tighter than the other. Get both wheels sticky to turn at 5-6 clicks. At 10 clicks out, the wheels had best be locked up solid. Let me know.
f) Test drive. Is pedal now firm (power brake boost noted) and not prone to dropping away?
Good, yer welcome. If it does still drop away, you need to go in and check. Usually it is a master cylinder failure (don't even tell me that it is "new", that means NOTHING THESE DAYS), but we could have an odd mechanical obstruction like bound up ebrake cross bar.
I personally think you just need a brake adjustment after your gallavanting around.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
-
- I'm New!
- Location: Noo Zelun' - left hand side...
- Contact:
- Status: Offline
Re: Brake weirdness - pedal drops...
Thanks Colin, looks like a fun weekend full of all my favourite jobs - I have a split CV boot to replace too, so I'll be following the unwritten last step in the CV cleaning / packing process...
Finally, clean up after yourself. This may require burning your house down and starting again.
Seems from what you've written and what I'm feeling is that something's not right in the front / rear brake balance. My rears probably are due an adjustment, but the braking performance feels really good right now - almost as if the fronts haven't been able to engage fully while the rears are correctly adjusted. Everything's even, no suggestion of any binding in the front calipers...
Perhaps the replacement master cylinder is at fault...I have the original, got that rebuilt - might be worth chucking that in and seeing if there's a perceptible difference.
Cheers, Simon
Finally, clean up after yourself. This may require burning your house down and starting again.
Seems from what you've written and what I'm feeling is that something's not right in the front / rear brake balance. My rears probably are due an adjustment, but the braking performance feels really good right now - almost as if the fronts haven't been able to engage fully while the rears are correctly adjusted. Everything's even, no suggestion of any binding in the front calipers...
Perhaps the replacement master cylinder is at fault...I have the original, got that rebuilt - might be worth chucking that in and seeing if there's a perceptible difference.
Cheers, Simon
-
- I'm New!
- Location: Noo Zelun' - left hand side...
- Contact:
- Status: Offline
Re: Brake weirdness - pedal drops...
I thought I'd report back...
Finally got around to adjusting the brakes this afternoon...when I came to set the parking brake, lo and behold, the passenger side refused to adjust up. Pulled the drum off and the crappy new c-clip on that bracer bar thingy had split and was rattling around the bottom of the drum, and the bar had popped off the stud. Found a replacement, adjusted her up and all is well.
Happy new year, all.
Finally got around to adjusting the brakes this afternoon...when I came to set the parking brake, lo and behold, the passenger side refused to adjust up. Pulled the drum off and the crappy new c-clip on that bracer bar thingy had split and was rattling around the bottom of the drum, and the bar had popped off the stud. Found a replacement, adjusted her up and all is well.
Happy new year, all.
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Brake weirdness - pedal drops...
jalabert wrote: ↑Fri Jan 03, 2020 10:34 pmI thought I'd report back...
Finally got around to adjusting the brakes this afternoon...when I came to set the parking brake, lo and behold, the passenger side refused to adjust up. Pulled the drum off and the crappy new c-clip on that bracer bar thingy had split and was rattling around the bottom of the drum, and the bar had popped off the stud. Found a replacement, adjusted her up and all is well.
Happy new year, all.
Thanks for the update. We're having quite the Happy New Year stuck here in Miami doing engine overhaul after engine overhaul.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles