A New Heart For Miss Zora
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
Is breaking in the rings different than the initial 20 minute break in?
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
Ahhhh...just answered my own question by re-reading the Aircooled.net post.
Now that the "bearing break in" is done, you want to REALLY heat the engine up by driving it hard! This loads the rings and will break the pistons, cylinders, and rings in together. I have found that engines that are missing the flaps or thermostat assembly have a tough time seating the rings in, and the only cure for this (my experience) is to get the engine HOT (some of these engines "never" break in). Find a hill and drive full throttle up the thing a few times, in a gear that loads the engine down a bit. The loading and extra heat burns the glaze off the cylinders and allows everything to seat together well. I do not feel a longer "break in" period is needed (some say 10,000 miles) other than getting the rings seated, and this can be done in 500 miles.
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
Did the ring break-in. 1st by doing it Colin's way up and down Vancouver and then I took her to 42nd to drive up and down that hill. I'm sure the neighbors thought I was nuts.
Got the oil changed, too.
See you in Nehalem!!!
Got the oil changed, too.
See you in Nehalem!!!
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
Took Miss Zora into the shop today just to make sure everything was OK and get the brakes done. holy s**t! I almost had an engine fire. That T over the top of the engine opened up and was spraying fuel on the engine. It was originally closed up with some orange gunk. I wrapped it up with fuel hose to keep it from dumping out but apparently didn't do that right. The battery wasn't properly grounded, I'm missing a part for the throttle body, all the vacuum lines were routed wrong and the points burned and closed. well, at least it made it into the shop! I'm very grateful for that. well, I don't feel so accomplished now. I'll get the report tomorrow. I feel sick.
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: A New Heart For Miss Zora
Did you witness this fuel "spraying" from the tee?misszora wrote:Took Miss Zora into the shop today
That T over the top of the engine opened up and was spraying fuel on the engine.
The battery wasn't properly grounded,
I'm missing a part for the throttle body,
all the vacuum lines were routed wrong
points burned and closed.
well, at least it made it into the shop!
How do you properly "ground" a battery?
What part was missing from the throttle body?
All the vacuum lines were routed wrong with John Shepski & friends help?
Was all of this pointed out to you, or was it a phone call from the WhiteKnightsRUs shop?
Fuel spraying from a vapor line tee?? Pshaw. Did you overfill the gas tank by a couple of gallons?
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
- LiveonJG
- IAC Jester!
- Location: Standing on the side of the road, rain falling on my shoes.
- Status: Offline
Re: A New Heart For Miss Zora
My thoughts exactly, without the Pshaw, of course. That should be vapor only in that tee.Amskeptic wrote:Fuel spraying from a vapor line tee?? Pshaw. Did you overfill the gas tank by a couple of gallons?
Colin
Keep it acoustic.
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
Thank you.
Yeah, it seems odd since it was running pretty good. I did not witness the fuel spray. I can't remember what part they were talking about because it made no sense to me - nothing seemed to be missing. I'll know more tomorrow and I will have the mechanic show me everything he's talking about.
Yeah, it seems odd since it was running pretty good. I did not witness the fuel spray. I can't remember what part they were talking about because it made no sense to me - nothing seemed to be missing. I'll know more tomorrow and I will have the mechanic show me everything he's talking about.
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: A New Heart For Miss Zora
Oh dear, I hope I did not offend anyone.LiveonJG wrote:My thoughts exactly, without the Pshaw, of course. That should be vapor only in that tee.Amskeptic wrote:Fuel spraying from a vapor line tee?? Pshaw. Did you overfill the gas tank by a couple of gallons?
Colin
I read it once, in The Road To Oz when the chicken Billina did not believe the Scarecrow. I had no idea she was swearing it up at him.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
No offense. Rather, empowerment. I felt like I failure but now I'm going to do a little investigating.
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- Bleyseng
- IAC Addict!
- Location: Seattle again
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
yes, sounds pretty strange to me...
Geoff
77 Sage Green Westy- CS 2.0L-160,000 miles
70 Ghia vert, black, stock 1600SP,- 139,000 miles,
76 914 2.1L-Nepal Orange- 160,000+ miles
http://bleysengaway.blogspot.com/
77 Sage Green Westy- CS 2.0L-160,000 miles
70 Ghia vert, black, stock 1600SP,- 139,000 miles,
76 914 2.1L-Nepal Orange- 160,000+ miles
http://bleysengaway.blogspot.com/
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
The missing part on the throttle body is the throttle switch. Not sure how that would be missing. She won't idle without it?
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- misszora
- IAC Addict!
- Location: Point Richmond, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
And yes, full tank of gas, crappy T.
Miss Zora - '77 VW Riviera Hard Top Campmobile
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
Dharma Bug - '69 VW Bug
The Vandejo - '74 VW Westfalia Poptop (former mom)
- Gypsie
- rusty aircooled mekanich
- Location: Treadin' Lightly under the Clear Blue!
- Status: Offline
Re: A New Heart For Miss Zora
Isn't there a charcoal canister setup that keeps the tank vent lines in a negative pressure condition? This 'overfilled tank issue' would show up with a overfull tank of gas while sitting? (ie no vacuum, no negative pressure, drip drip drip?) Jes curious...
Properly grounded = bolt down zone with corrosion?
Throttle enrichment switch? only kicks in at WOT. Idle won't be affected. make sure if there are connections from the harness that are not hooked up that they aren't flopping around making random ground circuits (or worse wired closed.)
seems like either minor bugs to iron out or a shop wanting to cultivate some bid'ness.
Properly grounded = bolt down zone with corrosion?
Throttle enrichment switch? only kicks in at WOT. Idle won't be affected. make sure if there are connections from the harness that are not hooked up that they aren't flopping around making random ground circuits (or worse wired closed.)
seems like either minor bugs to iron out or a shop wanting to cultivate some bid'ness.
So it all started when I wanted to get better gas mileage....
- Bleyseng
- IAC Addict!
- Location: Seattle again
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
You have the early 75 Ljet FI that uses the throttle switch? or is it just that there are a pair of wires sitting on the engine unused like on the later (76-79) setups.misszora wrote:The missing part on the throttle body is the throttle switch. Not sure how that would be missing. She won't idle without it?
Geoff
77 Sage Green Westy- CS 2.0L-160,000 miles
70 Ghia vert, black, stock 1600SP,- 139,000 miles,
76 914 2.1L-Nepal Orange- 160,000+ miles
http://bleysengaway.blogspot.com/
77 Sage Green Westy- CS 2.0L-160,000 miles
70 Ghia vert, black, stock 1600SP,- 139,000 miles,
76 914 2.1L-Nepal Orange- 160,000+ miles
http://bleysengaway.blogspot.com/
-
- Addicted!
- Location: Quartz Hill, CA
- Contact:
- Status: Offline
Re: A New Heart For Miss Zora
No failure in my book! You touched EVERY nut and bolt on and around that engine and it runsmisszora wrote:No offense. Rather, empowerment. I felt like I failure but now I'm going to do a little investigating.
1968 Karmann Ghia - Driver
1969 Transporter - Project
1959 Karmann Ghia - Full Race Car
1969 Transporter - Project
1959 Karmann Ghia - Full Race Car